This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
Remedy & full details
Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.
This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.
Serious10V254000
Seat Belts:Front:Retractor
THE INSULATION AROUND THE PRE-TENSIONER COULD IGNITE.
Remedy & full details
VEHICLES PRODUCED UP THROUGH DECEMBER 2009 WILL RECEIVE NEW FRONT SAFETY BELT RETRACTOR UNITS AND A MODIFICATION TO THE SOUND INSULATION NEAR THE UNITS, WHILE VEHICLES PRODUCED BETWEEN JANUARY 2010 AND MAY 2010 WILL RECEIVE A MODIFICATION TO THE SOUND INSULATION NEAR THE UNITS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 23, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
BMW IS RECALLING CERTAIN MODEL YEAR 2008-2011 1-SERIES VEHICLES. IN A CRASH OF SUFFICIENT SEVERITY, DEPLOYMENT OF THE FRONT PRE-TENSIONER AND LOAD-LIMITER OCCURS.
Serious09V257000
Air Bags:Frontal
IF THAT HAPPENED, IT WOULD BE POSSIBLE FOR THE SIDE AIR BAG AND/OR THE SAFETY BELT TENSIONER NOT TO DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, raises the risk of INJURIES.
Remedy & full details
BMW WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2009. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES TOLL-FREE AT 1-800-525-7417.
BMW IS RECALLING 2,350 MY 2008 1-SERIES AND 3- SERIES PASSENGER CARS. INCORRECT CRIMP CONNECTORS MAY HAVE BEEN USED ON THE SIDE AIR BAG AND BELT TENSIONER WIRING. AS A RESULT SUFFICIENT CONTACT BETWEEN THE CRIMP CONNECTORS AND THE CORRESPONDING PLUG MAY NOT OCCUR WHICH COULD LEAD TO AN INCREASE IN THE ELECTRICAL RESISTANCE OF THAT CONNECTION.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
Complaints filed
24
Reporting a crash
1
Reporting a fire
0
Injuries reported
0
Deaths reported
0
Severity Index
0.08
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Air Bags — 6 reports
Exterior Lighting — 5 reports
Fuel/Propulsion System — 3 reports
Seats — 3 reports
Engine — 2 reports
Electrical System — 2 reports
Power Train — 1 reports
Steering — 1 reports
Seat Belts — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.