Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy & full details
DEALERS WILL INSPECT AND REPLACE THE FUEL LINES FREE OF CHARGE. THE RECALL BEGAN DURING APRIL 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW IS RECALLING 1,391 MY 2007 G650X CHALLENGE, COUNTRY, AND MOTO MOTORCYCLES. THE FUEL LINES MAY HAVE BEEN DAMAGED DURING PRODUCTION, AND COULD DEVELOP A LEAK. THE LEAK COULD OCCUR EITHER THROUGH THE FABRIC INLAY AT THE END OF THE LINE, OR, THROUGH A CRACK IN THE ACTUAL LINE.
Serious08V111000
Suspension:Rear
IF THIS HAPPENED, THE BRAKES WOULD REMAIN FULLY AVAILABLE TO SLOW AND STOP THE MOTORCYCLE.
Remedy & full details
DEALERS WILL CHECK AND INSTALL A CORRECT CIRCLIP, ALONG WITH A NEW SPACER BUSHING, WHEEL BEARINGS, AND SHAFT SEALING RINGS FREE OF CHARGE. THE RECALL BEGAN DURING APRIL 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRONG CIRCULAR CLIP INSTALLED ON THE LEFT HAND SIDE OF THE REAR WHEEL BEARING GUIDE. THIS CIRCLIP CAN RUB AGAINST A SPACER BUSHING, CREATING METAL SHAVINGS WHICH MAY ENTER THE WHEEL BEARING, CAUSING IT TO FAIL AND THE ANTILOCK BRAKE SYSTEM (ABS) MAY MALFUNCTION. THIS WOULD BE INDICATED BY ILLUMINATION OF THE ABS WARNING LAMP.
Serious07V367000
Engine And Engine Cooling:Engine
LOOSENING OF THE CHAIN TENSIONER AND THE REAR WHEEL AXLE MAY OCCUR.
Remedy & full details
DEALERS WILL INSTALL A NEW RIGHT SIDE CHAIN TENSIONER FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 13, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
ON CERTAIN MOTORCYCLES, A LEFT-SIDE CHAIN TENSIONER HAS BEEN INCORRECTLY INSTALLED ON THE RIGHT SIDE. AS A RESULT, A HEX NUT, WHICH IS USED TO SECURE THE CHAIN TENSIONER, IS IMPROPERLY SEATED AGAINST THE TENSIONER.
Serious07V376000
Fuel System, Gasoline:Delivery:Fuel Pump
THE FUEL PUMP WILL FAIL AND FUEL DELIVERY TO THE ENGINE WOULD CEASE CAUSING THE ENGINE TO STALL raises the risk of A CRASH.
Remedy & full details
DEALERS WILL REPLACE THE FUEL PUMP UNIT WIRING SET FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
ON CERTAIN MOTORCYCLES, THE FUEL PUMP WIRING SET HAS NOT BEEN MANUFACTURED ACCORDING TO SPECIFICATION. THE CONTACTS IN THE PLUG FOR THE FUEL PUMP CAN BREAK.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
0Fires
0Injuries
0Deaths
Across 3 complaints. Severity Index 0.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Electrical System — 1 reports
Fuel System, Gasoline — 1 reports
Service Brakes, Hydraulic — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Other model years
2007
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.