How many recalls does the 2005 Bmw K1200 S have?

5 open NHTSA safety recalls are on record for the 2005 Bmw K1200 S, alongside 19 owner complaints.

Home → Bmw → K1200 S → 2005

2005 Bmw K1200 S Recalls & Complaints

open safety recalls on record

Critical

19 owner complaints filed · Severity Index 2.32 · updated 2026-08-07

The recalls

Critical20V471000

Fuel System, Gasoline:Delivery:Fuel Pump

fuel leak in the presence of an ignition source can raises the risk of a fire.

Remedy & full details

BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Critical07V066000

Engine And Engine Cooling

IT IS POSSIBLE THAT A PRESSURE BUILD UP IN THE OIL TANK COULD CAUSE IT TO RUPTURE, ALLOWING OIL TO LEAK ONTO THE REAR TIRE.

Remedy & full details

DEALERS WILL INSTALL A NEW OIL TANK CAP CONTAINING A VALVE TO PREVENT OVERPRESSURE IN THE TANK FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

ON CERTAIN MOTORCYCLES, FREQUENT SHORT TRIPS PARTICULARLY DURING COLD TEMPERATURES, CAN CAUSE WATER TO ACCUMULATE IN THE OIL TANK, AND WHEN THE ENGINE IS RUNNING, ESCAPING WATER VAPOR CAN CONDENSE ON THE OIL TANK AIR BLEED VALVE. IN FREEZING TEMPERATURES, THIS WATER COULD FREEZE AND BLOCK THE AIR BLEED VALVE.

Serious06V164000

Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip

TEMPORARY LOSS OF ABS BRAKING COULD raises the risk of A CRASH.

Remedy & full details

DEALERS WILL ADD A PHYSICAL RESTRICTION, IN THE FORM OF A BANJO BOLT WITH A FLOW RESTRICTOR TO THE BRAKE LINE, AND ON CERTAIN MODELS DEALERS WILL INSTALL NEW FRONT BRAKE DISCS OF A SLIGHTLY LARGER THICKNESS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006, AND WILL BE A PHASED MAILING THROUGH OCTOBER 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

ON CERTAIN MOTORCYCLES, UNDER RAPID, REPEATED, AND UNUSUALLY HARSH BRAKING, LOSS OF ABS CAPABILITY COULD TEMPORARILY OCCUR.

Serious10V488000

Suspension:Rear

THIS COULD AFFECT THE HANDLING OF THE MOTORCYCLE INCREASING THE RISK A DRIVER MAY LOSE CONTROL OF THE VEHICLE RESULTING IN A CRASH.

Remedy & full details

BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

BMW IS RECALLING CERTAIN MODEL YEAR 2005-2011 MOTORCYCLES. THE BEARINGS COULD BE SUBJECT TO CORROSION. THIS COULD LEAD TO REDUCED MOVEMENT OF THE LINK LEVER.

Serious05V363000

Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip

THE SENSOR CABLE CAN COME INTO CONTACT WITH, AND RUB AGAINST, THE FRONT BRAKE DISK.

Remedy & full details

DEALERS WILL INSPECT AND ATTACH AN ADDITIONAL RETAINING CLIP TO THE IABS SENSOR CABLE FREE OF CHARGE. THE RECALL BEGAN SEPTEMBER 23, 2005. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

ON CERTAIN MOTORCYCLES, THERE COULD BE A PROBLEM WITH THE ROUTING OF THE INTEGRAL ANTI-LOCK-BRAKE SYSTEM (IABS) SENSOR CABLE IF SERVICE HAS BEEN PERFORMED ON THE MOTORCYCLE, FOR EXAMPLE, A FRONT TIRE CHANGE.

Complaint volume

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

What owners reported happened

4Crashes

0Fires

4Injuries

2Deaths

Across 19 complaints. Severity Index 2.32.

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

Fuel/Propulsion System — 5 reports
Service Brakes — 3 reports
Fuel System, Gasoline:Delivery — 1 reports
Engine And Engine Cooling — 1 reports
Power Train:Manual Transmission — 1 reports
Suspension:Rear — 1 reports
Power Train — 1 reports
Fuel System, Gasoline — 1 reports
Engine And Engine Cooling:Engine — 1 reports
Engine — 1 reports

What to do

Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

2003 (1) · 2004 (1) · 2005 · 2006 (4) · 2007 (5) · 2008 (5)

Numbers in brackets are open recall campaigns for that year.

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit

Is that tyre actually right for your car?

2,808 fitment guides

FuelFacts

What that trip really costs in fuel

Live consumption data

CostCompare

What things cost, city by city

2,123 comparisons