RecallRadar

Home → Bmw → X5 → 2004

2004 Bmw X5 Recalls & Complaints

4

open safety recalls on record

Critical

93 owner complaints filed · Severity Index 0.85 · updated 2026-08-07

The recalls

Critical04V344000

Power Train:Automatic Transmission:Control Module (Tcm/Pcm/Tecm)

AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION.

Remedy & full details

DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.

Critical04V402000

Fuel System, Gasoline:Delivery:Fuel Pump

ENGINE STALLING COULD OCCUR, EVEN THOUGH THE VEHICLE'S FUEL GAUGE INDICATES THAT FUEL IS PRESENT IN THE TANK.

Remedy & full details

DEALERS WILL INSPECT THE IN-TANK SUCTION JET PUMP FUEL LINE AND IF NECESSARY, REATTACH ACCORDING TO SPECIFICATIONS. THIS RECALL BEGAN SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.

Serious03V475000

Power Train:Driveline:Differential Unit

WITH PROLONGED DRIVING, THESE BOLTS COULD BECOME LOOSE, CAUSE DAMAGE TO THE ENGINE AND TRANSMISSION HOUSINGS.

Remedy & full details

DEALERS WILL INSPECT AND RETIGHTEN THE DRIVETRAIN FASTENERS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.

Serious04V409000

Power Train:Clutch Assembly:Pedal/Hand Lever(Motorcycle)

THE VEHICLE COULD ACCELERATE UNEXPECTEDLY, WHICH COULD RESULT IN A CRASH.

Remedy & full details

DEALERS WILL REPROGRAM THE VEHICLE'S DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.

Complaint volume

93 this model-year 6 median, same year

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

Complaints filed93
Reporting a crash4
Reporting a fire13
Injuries reported8
Deaths reported0
Severity Index0.85

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

  1. Electrical System — 10 reports
  2. Engine — 9 reports
  3. Latches/Locks/Linkages — 7 reports
  4. Power Train — 7 reports
  5. Seats — 5 reports
  6. Power Train:Automatic Transmission — 4 reports
  7. Steering — 4 reports
  8. Air Bags — 4 reports
  9. Suspension — 3 reports
  10. Exterior Lighting — 3 reports

What to do

  1. Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
  2. Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
  3. Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

2000 · 2001 · 2002 · 2003 · 2004 · 2005 · 2006 · 2007 · 2008 · 2009 · 2010 · 2011 · 2012 · 2013 · 2014 · 2015 · 2016 · 2017 · 2018 · 2019 · 2020 · 2021 · 2022 · 2023 · 2024 · 2025 · 2026

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit
Is that tyre actually right for your car?
2,808 fitment guides
FuelFacts
What that trip really costs in fuel
Live consumption data
CostCompare
What things cost, city by city
2,123 comparisons