DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Critical07V349000
Fuel System, Gasoline:Storage
FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK.
Remedy & full details
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Critical03V454000
Fuel System, Gasoline:Storage
IF THESE PARTS SEPARATE, THE DRIVER MAY NOTICE AN ODOR OF FUEL, THE SERVICE ENGINE SOON OR CHECK ENGINE LIGHT MAY ILLUMINATE, AND/OR FUEL MAY LEAK ONTO THE GROUND.
Remedy & full details
DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.
Serious05V157000
Electrical System:Ignition
THE VEHICLE CANNOT BE RESTARTED IMMEDIATELY.
Remedy & full details
DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
Serious04V150000
Latches/Locks/Linkages:Hatchback/Liftgate:Lock
IF THE LIFTGATE WERE TO OPEN IN A VEHICLE CRASH, AN OCCUPANT COULD BE EJECTED FROM THE VEHICLE RESULTING IN INCREASED RISK OF PERSONAL INJURY.
Remedy & full details
DEALERS WILL ADD STRUCTURAL REINFORCEMENTS TO THE LIFTGATE IN THE AREA ADJOINING THE LATCH ASSEMBLY. OWNER NOTIFICATION SCHEDULE BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. THIS IS AN EXPANSION TO A PREVIOUS RECALL (03V211).
ON CERTAIN SPORT UTILITY VEHICLES, A STRUCTURAL SUPPORT AT THE LATCH ATTACHMENT IN THE REAR LIFTGATE MAY BE INADEQUATE TO RETAIN THE LATCH TO THE LIFTGATE IN CERTAIN SEVERE VEHICLE CRASH EVENTS.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
16Crashes
2Fires
21Injuries
2Deaths
Across 300 complaints. Severity Index 0.47.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Electrical System — 47 reports
Fuel/Propulsion System — 20 reports
Steering — 14 reports
Electrical System:Ignition — 14 reports
Engine And Engine Cooling — 12 reports
Fuel System, Gasoline — 11 reports
Service Brakes — 11 reports
Air Bags — 10 reports
Engine — 10 reports
Unknown Or Other — 9 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.