SHOULD THE DIODE FAIL, IT WILL BE POSSIBLE TO MOVE THE VEHICLE WITH THE WHEELCHAIR DEPLOYED, WHICH COULD RESULT IN INJURY TO ANYONE USING THE LIFT.
Remedy & full details
INTERMOTIVE WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 20, 2007. OWNERS CAN CONTACT INTERMOTIVE TOLL-FREE AT 1-800-969-6080. THIS RECALL ONLY PERTAINS TO AFTERMARKET INTERMOTIVE WHEELCHAIR LIFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVRLOT AND GMC VEHICLES MANUFACTURED BY GENERAL MOTORS.
CERTAIN INTERMOTIVE WHEELCHAIR LIFT INTERLOCK, P/NO. ILIS605-H3 ILIS ACTIVATION KIT (INTERLOCK OPTION FOR GATEWAY 401) SOLD FOR USE AS AFTERMARKET FOR 2005 - 2008 CHEVY 560 (C4500 AND C5500 KODIAK) 6.6L DIESEL VEHICLES WHICH A PROTECTION DIODE WAS USED. THE DIODE CAN BE EXPOSED TO VOLTAGE SPIKES GREATER THAN WHAT IT CAN WITHSTAND. THE DIODE COULD FAIL, WHICH COULD PREVENT VEHICLE INTERLOCK OPERATION WHEN A WHEELCHAIR LIFT IS DEPLOYED.
Serious12V584000
Equipment
wheelchair occupant may defeat or ride over the insufficiently latched roll stop.
Remedy & full details
Braun is conducting this recall on behalf of Creative Bus Sales. Braun will notify owners, and dealers will repair the vehicles free of charge. The recall began on November 23, 2012. Owners may contact Creative Bus at 1-888-633-8380 or Braun at 1-800-488-0359.
Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.
Moderate07E086000
Suspension
IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.
Remedy & full details
LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
1Fires
0Injuries
0Deaths
Across 11 complaints. Severity Index 0.27.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Suspension:Rear:Shock Absorber — 1 reports
Suspension:Front — 1 reports
Fuel System, Diesel — 1 reports
Exterior Lighting — 1 reports
Suspension:Rear — 1 reports
Engine And Engine Cooling:Engine:Diesel — 1 reports
Engine And Engine Cooling — 1 reports
Engine — 1 reports
Engine And Engine Cooling:Cooling System:Radiator Assembly — 1 reports
Service Brakes — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.