RecallRadar

Home → Chevrolet → Lumina → 1996

1996 Chevrolet Lumina Recalls & Complaints

3

open safety recalls on record

Critical

312 owner complaints filed · Severity Index 1.07 · updated 2026-08-07

The recalls

Critical07E021000

Fuel System, Other:Storage:Tank Assembly:Pressure Relief Devices

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy & full details

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Serious96V122000

Service Brakes, Hydraulic:Power Assist:Vacuum

IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.

Remedy & full details

DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.

THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.

Moderate96V069000

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

THIS CONDITION CAN CAUSE THE BRAKE LINE TO WEAR THROUGH, RESULTING IN LOSS OF BRAKE FLUID AND EVENTUAL LOSS OF ONE-HALF OF THE VEHICLE'S BRAKE SYSTEM, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy & full details

DEALERS WILL INSPECT THE VEHICLE FOR PROPER BRAKE LINE CLEARANCE AND REPOSITION THOSE BRAKE LINES FOUND TO HAVE LESS THAN MINIMAL CLEARANCE. ADDITIONALLY, THOSE BRAKE LINES FOUND TO HAVE AN INDENTATION CAUSED BY THE CONTACT WILL BE REPLACED AND PROPERLY ROUTED.

THE LEFT FRONT BRAKE LINE CAN CONTACT THE TRANSAXLE MOUNTING BRACKET OR ATTACHMENT BOLT.

Complaint volume

312 this model-year 8 median, same year

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

What owners reported happened

34Crashes
3Fires
42Injuries
9Deaths

Across 312 complaints. Severity Index 1.07.

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

Power Train · Automatic T…18 · 6%Air Bags · Frontal18 · 6%Air Bags16 · 5%Service Brakes, Hydraulic…12 · 4%Unknown Or Other11 · 4%Engine And Engine Cooling…9 · 3%Engine And Engine Cooling9 · 3%Engine And Engine Cooling…8 · 3%
  1. Power Train:Automatic Transmission — 18 reports
  2. Air Bags:Frontal — 18 reports
  3. Air Bags — 16 reports
  4. Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip — 12 reports
  5. Unknown Or Other — 11 reports
  6. Engine And Engine Cooling:Engine:Gasoline — 9 reports
  7. Engine And Engine Cooling — 9 reports
  8. Engine And Engine Cooling:Engine — 8 reports
  9. Engine And Engine Cooling:Cooling System — 8 reports
  10. Electrical System:Horn — 6 reports

What to do

  1. Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
  2. Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
  3. Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

1995 (7) · 1996 · 1997 (2) · 1998 (4) · 1999 (3) · 2000 (6) · 2001 (4)

Numbers in brackets are open recall campaigns for that year.

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit
Is that tyre actually right for your car?
2,808 fitment guides
FuelFacts
What that trip really costs in fuel
Live consumption data
CostCompare
What things cost, city by city
2,123 comparisons