RecallRadar

Home → Chevrolet → Monte Carlo → 1996

1996 Chevrolet Monte Carlo Recalls & Complaints

3

open safety recalls on record

Critical

255 owner complaints filed · Severity Index 0.35 · updated 2026-08-07

The recalls

Critical07E021000

Fuel System, Other:Storage:Tank Assembly:Pressure Relief Devices

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy & full details

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Serious96V122000

Service Brakes, Hydraulic:Power Assist:Vacuum

IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.

Remedy & full details

DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.

THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.

Moderate01I014000

Service Brakes, Hydraulic:Foundation Components

THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.

Remedy & full details

DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.

Complaint volume

255 this model-year 8 median, same year

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

What owners reported happened

21Crashes
1Fires
11Injuries
0Deaths

Across 255 complaints. Severity Index 0.35.

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

Service Brakes, Hydraulic…33 · 13%Electrical System · Ignit…16 · 6%Electrical System · Ignit…16 · 6%Electrical System · Alter…13 · 5%Engine And Engine Cooling…11 · 4%Engine And Engine Cooling…9 · 4%Fuel System, Gasoline · F…9 · 4%Unknown Or Other9 · 4%
  1. Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip — 33 reports
  2. Electrical System:Ignition — 16 reports
  3. Electrical System:Ignition:Module — 16 reports
  4. Electrical System:Alternator/Generator/Regulator — 13 reports
  5. Engine And Engine Cooling:Engine — 11 reports
  6. Engine And Engine Cooling:Engine:Gasoline — 9 reports
  7. Fuel System, Gasoline:Fuel Injection System — 9 reports
  8. Unknown Or Other — 9 reports
  9. Power Train:Automatic Transmission — 9 reports
  10. Structure:Body:Door — 7 reports

What to do

  1. Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
  2. Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
  3. Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

1995 (5) · 1996 · 1997 (3) · 1998 (5) · 1999 (5) · 2000 (8) · 2001 (8) · 2002 (7) · 2003 (9) · 2004 (7) · 2005 (4) · 2006 (2) · 2007 (2) · 2008 · 2010

Numbers in brackets are open recall campaigns for that year.

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit
Is that tyre actually right for your car?
2,808 fitment guides
FuelFacts
What that trip really costs in fuel
Live consumption data
CostCompare
What things cost, city by city
2,123 comparisons