EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Remedy & full details
COACHMEN IS WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COACHMEN AT 574-825-5821.
COACHMEN IS RECALLING 37,293 MOTORHOMES AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Critical05V294000
Electrical System
WHEN THE TORQUE IS RELAXED, THE LUGS CAN BECOME LOOSE RESULTING IN EXCESSIVE HEAT WITHIN THE CONNECTED WIRE THAT COULD RESULT IN A FIRE.
Remedy & full details
COACHMEN WILL BE WORKING WITH INTELLITEC TO NOTIFY OWNERS AND HAVE THE REPAIR PERFORMED ON THEIR VEHICLES. THE RECALL BEGAN ON JULY 14, 2005. OWNERS MAY CONTACT COACHMEN AT 1-574-825-1174.
ON CERTAIN REAR DIESEL MOTOR HOMES CONTAINING A 50 AMP TRANSFER SWITCH BUILT BY INTELLITEC, THE MATERIAL USED FOR THE WIRE LUGS WAS CHANGED FROM NICKEL PLATED TO COPPER LUGS. THE COPPER LUGS ARE SOFTER THAN THE NICKEL PLATED AND DO NOT RETAIN THE TORQUE OF THE SCREW THAT CLAMPS THE WIRE CONNECTOR.
Serious08V193000
Steering:Hydraulic Power Assist System
SUDDEN LOSS OF STEERING ASSIST WITHOUT WARNING INVOLVING A MOTOR HOME COULD BE A PROBLEM FOR CERTAIN DRIVERS raises the risk of A CRASH.
Remedy & full details
COACHMEN IS WORKING WITH FREIGHTLINER TO REPLACE THE AFFECTED FILTERS WITH A LARGER FILTER (PLEASE SEE 07V570). OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR COACHMEN AT 1-574-825-5821.
COACHMEN IS RECALLING 961 MY 2005-2007 CROSS COUNTRY, SPORTSCOACH ELITE, MY 2005-2006 CROSS COUNTRY SE, AND MY 2006 SPORTSCOACH ENCORE CLASS A MOTOR HOMES BUILT USING INLINE POWER STEERING FILTERS, PART NO. 14-16829-000. THE FILTER CAN PLUG DUE TO FAILURE OF THE SCREEN ADHESION TO THE FILTER HOUSING CAUSING A RISE IN RETURN LINE PRESSURE. THIS CAN LEAD TO HOSE SEPARATION FROM THE FILTER OR STEERING GEAR FITTING RESULTING IN A SUDDEN LOSS OF STEERING FLUID AND POWER ASSIST.
Serious08V639000
Equipment:Recreational Vehicle/Trailer
GLASS BREAKAGE MAY OCCUR WHICH COULD CAUSE PERSONAL INJURY.
Remedy & full details
OWNERS WILL BE PROVIDED WITH NEW MOUNTING HARDWARE FOR THE TOWEL BAR AND INSTALLATION INSTRUCTIONS. IF AN OWNER IS NOT COMFORTABLE REPLACING THE HARDWARE THEMSELVES, A DEALER WILL INSTALL THE HARDWARE AT NO COST TO THEM. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 19, 2008. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.
COACHMEN IS RECALLING 13,662 MY 2002-2008 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH GLASS SHOWER DOORS AND MANUFACTURED FROM JUNE 15, 2001 THORUGH AUGUST 6, 2007. WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
Complaints filed
2
Reporting a crash
0
Reporting a fire
0
Injuries reported
0
Deaths reported
0
Severity Index
0.00
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Electrical System — 1 reports
Visibility:Windshield Wiper/Washer — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.