2004 Fleetwood Terry Recalls & Complaints

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

DEALERS WILL INSPECT AND, AS NECESSARY, REROUTE THE PROPANE GAS LINE. THIS RECALL BEGAN ON OCTOBER 24, 2005. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.

ON CERTAIN FIFTH WHEEL TRAILERS, THE PROPANE GAS LINES THAT RUN THROUGH THE FLOOR OF THE SLIDE OUT ROOM PENETRATE THE FLOOR TOO FAR FROM THE OUTSIDE WALL CAUSING THE POTENTIAL FOR PINCHED LINES DURING SLIDE OUT ROOM OPERATION.

FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

OWNERS WILL BE PROVIDED WITH A LABEL AND INSERT TO BE ADDED TO THE OWNER'S MANUAL. IF THE VEHICLE HAS THE "ALUMINUM WHEEL" OPTION, OWNERS ARE REQUESTED TO BRING THEIR VEHICLE INTO A DEALER TO HAVE THE WHEEL LUG NUTS TORQUED TO THE PROPER SPECIFICATIONS. OWNER NOTIFICATION BEGAN NOVEMBER 26, 2003. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.

ON CERTAIN CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS, THE OWNER MANUALS EITHER DO NOT CONTAIN THE WHEEL LUG NUT TORQUE INFORMATION OR CONTAIN INCORRECT WHEEL LUG NUT TORQUE INFORMATION FOR THE OPTIONAL "ALUMINUM WHEEL"

DEALERS WILL INSPECT, REPAIR, OR REPLACE ANY DAMAGED WHEELS, LUG NUTS, LUG STUDS, AND MATING SURFACES. DEALERS WILL ALSO REMOVE PAINT FILM FROM THE MATING SURFACES. THE RECALL BEGAN ON AUGUST 5, 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-509-3418.

ON CERTAIN FIFTH WHEEL AND CONVENTIONAL TRAVEL TRAILERS EQUIPPED WITH ALUMINUM WHEELS MAY NOT HAVE HAD THE PROPER WHEEL LUG NUT TORQUE APPLIED. ADDITIONALLY, PAINT APPLIED TO THE MATING SURFACE OF THE HUB MAY CAUSE THE LUG NUTS TO BE MORE SENSITIVE TO LOOSENING DURING THE INITIAL SETTLING-IN OF COMPONENTS AND AFTER A WHEEL HAS BEEN REMOVED FOR SERVICE.

DEALERS WILL INSPECT AND REPLACE THE CIRCUIT BREAKER IF NECESSARY. OWNER NOTIFICATION IS EXPECTED TO BEGIN BY APRIL 5, 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

ON CERTAIN CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH SIEMENS Q CIRCUIT BREAKER, THE CIRCUIT BREAKERS WERE MIS-MARKED.

DEALERS WILL INSPECT AND REPLACE TIRES THAT ARE MARKED "LOAD RANGE "B" AND REPLACE IT WITH A "LOAD RANGE "C" TIRE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT FLEETWOOD AT 1-800-445-3307.

CERTAIN TRAVEL TRAILERS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE TIRE AND LOADING INFORMATION PLACARD CONTAINS INCORRECT "LOAD RANGE "B" INFORMATION REGARDING THE MAXIMUM CARGO CARRYING CAPACITY. THE CORRECT TIRE IS A LOAD RANGE "C".

LIPPERT COMPONENTS, IN CONJUNCTION WITH FLEETWOOD, WILL INSPECT THE CROSS-MEMBERS FOR MISSING WELDS, REPAIR THE WELDS IF NECESSARY, AND ADD ADDITIONAL SUPPORT TO THE AFFECTED AREA. OWNERS MAY CONTACT LIPPERT DIRECTLY AT 1-866-524-7821 TO MAKE ARRANGEMENTS TO HAVE THIS INSPECTION AND REPAIR PERFORMED. THE RECALL BEGAN ON AUGUST 4, 2005.

CERTAIN FIFTH WHEEL TRAVEL TRAILERS HAVE MISSING WELDS ON THE CHASSIS CROSS-MEMBERS.