SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy & full details
DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Critical05V266000
Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings
THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE.
Remedy & full details
DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Serious20E090000
Steering
If the steering locks, it can raises the risk of a crash.
Remedy & full details
Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.
Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Serious11V352000
Exterior Lighting:Tail Lights
NON-FUNCTIONING LIGHTS COULD raises the risk of A CRASH.
Remedy & full details
DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Moderate08E026000
Equipment
THIS COULD ALLOW POSSIBLE SHIFTING AND DAMAGE TO THE REAR DRIVE SHAFT AND AXLE.
Remedy & full details
TRUXXX WILL NOTIFY CUSTOMERS/INSTALLERS AND WILL REPLACE AFFECTED WELDED LIFT BLOCKS WITH EITHER NON-WELDED ALUMINUM OR CAST IRON BLOCKS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 16, 2008. OWNERS MAY CONTACT TRUXXX AT 1-800-381-8320.
TRUXXX IS RECALLING 338 AFTERMARKET REPLACEMENT WELDED 3" LIFT BLOCKS FOR REAR SUSPENSIONS, PART NO. 206073, INCLUDED IN SUSPENSION KIT NOS. 108035 AND 108036, SOLD BETWEEN JULY 26, 2007 AND MARCH 4, 2008, FOR USE ON FORD MY 2005-2008 F-250 SUPERDUTY 4X4 LIGHT TRUCKS. COMPRESSIVE FORCES OF THE WELDED LIFT BLOCKS RESULTING FROM FORESEEABLE AND EXCESS VEHICLE PAYLOADS AS WELL AS OVER-TIGHTENING OF THE U-BOLTS DURING INSTALLATION MAY DISTORT THE BLOCKS, REDUCING THE INTENDED CLAMPING FORCE OF THE U-BOLTS.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
9Crashes
7Fires
13Injuries
0Deaths
Across 381 complaints. Severity Index 0.24.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Suspension:Front — 68 reports
Steering — 65 reports
Suspension — 46 reports
Electrical System — 21 reports
Engine And Engine Cooling — 13 reports
Fuel System, Diesel — 13 reports
Service Brakes, Hydraulic — 10 reports
Engine — 10 reports
Engine And Engine Cooling:Engine:Diesel — 9 reports
Engine And Engine Cooling:Engine — 9 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.