DEALERS WILL INSTALL A NEW SEALED RELAY AND FUSE BOX WITH SEALED RELAYS. OWNER NOTIFICATION BEGAN JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
VEHICLE DESCRIPTION: STEP VANS. WATER COULD ENTER THE ELECTRICAL RELAYS RESULTING IN AN ELECTRICAL SHORT.
Serious05V138000
Equipment:Other:Labels
THIS COULD CAUSE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING WHICH COULD CAUSE A CRASH.
Remedy & full details
DEALERS WILL MAIL NEW CHASSIS IDENTIFICATION LABELS WITH THE CORRECT GAWR, GVWR, AND TIRE INFORMATION. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
Serious01V140007
Steering:Linkages:Tie Rod Assembly
THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, raises the risk of LOSS OF CONTROL OF THE VEHICLE.
Remedy & full details
DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.
Serious01V117000
Electrical System:Wiring
THIS RESULTS IN A LOSS OF POWER ASSIST TO THE BRAKE SYSTEM, raises the risk of A CRASH.
Remedy & full details
DEALERS WILL REWIRE THE BACK-UP BRAKE PUMP CIRCUIT. OWNER NOTIFICATION BEGAN JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
VEHICLE DESCRIPTION: STEP VANS. THE BACK-UP BRAKE PUMP WAS WIRED TO A 25 AMP FUSED CIRCUIT INSTEAD OF THE REQUIRED 50 AMP FUSED CIRCUIT. IF THE BACK-UP HYDRAULIC BRAKE PUMP WERE TO ENGAGE DUE TO A FAILURE IN THE PRIMARY BRAKE ASSIST SYSTEM OR THE BRAKES ARE APPLIED WITHOUT THE ENGINE RUNNING, THE FUSE COULD BLOW.
Serious00V229001
Power Train:Automatic Transmission
THIS COULD CAUSE NON-ENGAGEMENT OF THE PARK PAWL WHEN THE TRANSMISSION SHIFT SELECTOR IS MOVED TO THE PARK POSITION, RESULTING IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy & full details
ALLISON TRANSMISSION IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REMOVE THE TRANSMISSION FROM THE VEHICLE, REPLACE THE PARK PAWL, AND REINSTALL THE TRANSMISSION IN THE VEHICLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ALLISON AT 1-800-252-5283 OR FREIGHTLINER AT 1-800-547-0712.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, SHUTTLE BUSES, TRANSIT BUSES AND STEP VANS EQUIPPED WITH ALLISON 1000 OR 2400 SERIES TRANSMISSIONS. THESE TRANSMISSIONS CAN EXPERIENCE PARK PAWL TO REAR COVER INTERFERENCE DUE TO AN OUT OF FLATNESS CONDITION.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
0Fires
0Injuries
0Deaths
Across 2 complaints. Severity Index 0.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Fuel System, Gasoline:Fuel Injection System — 1 reports
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.