STEP TREAD SEPARATION WHILE A PERSON IS ENTERING OR EXITING THE CAB, MAY RESULT IN PROPERLY DAMAGE OR PERSONAL INJURY.
Remedy & full details
DEALERS WILL INSTALL REINFORCED METAL BRACKETS ON BOTH CAB ENTRY STEP PLATFORMS. THE RECALL BEGAN ON DECEMBER 2, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
ON CERTAIN TRUCKS, THE CAB ENTRY STEPS WERE MANUFACTURED INCORRECTLY CAUSING THEM TO HAVE LOWER MATERIAL STRENGTH PROPERTIES THAN DESIGNED. THESE LOWER MATERIAL STRENGTH PROPERTIES CAN ALLOW THE STEP TREAD TO FRACTURE AND SEPARATE FROM THE VEHICLE UNDER NORMAL USAGE.
Serious06V489000
Structure:Body
THIS SEPARATION CAN OCCUR WITHOUT WARNING AND POSSIBLY CONTRIBUTE TO PERSONAL INJURY.
Remedy & full details
DEALERS WILL REPLACE THE CAB ENTRY/EGRESS GRAB HANDLE. THE RECALL BEGAN ON FEBRUARY 16, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
ON CERTAIN TRUCKS, THE A-PILLAR MOUNTED ENTRY/EGRESS GRAB HANDLE MAY LOOSEN AND POSSIBLY SEPARATE FROM THE VEHICLE.
Serious06V378000
Electrical System
IF THIS OCCURS, ERRATIC BEHAVIOR OF THE IPR VALVE CAN CAUSE THE ENGINE TO SHUT DOWN WITHOUT WARNING WHILE THE VEHICLE IS IN OPERATION.
Remedy & full details
DEALERS WILL INSPECT FOR CORROSION AND IF A SIGNIFICANT AMOUNT IS PRESENT, THE CONNECTOR WILL BE REMOVED AND A NEW, SEALED CONNECTOR INSTALLED. IF NO CORROSION IS PRESENT, THE CONNECTOR WILL BE CLEANED, FILLED WITH DIELECTRIC GREASE AND COVERED WITH A PROTECTIVE WRAP THAT WILL PREVENT FUTURE CORROSION OF THE CONNECTOR TERMINALS. THE RECALL BEGAN ON NOVEMBER 9, 2006. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
ON CERTAIN TRUCKS EQUIPPED WITH VT-275 ENGINES, THE ELECTRICAL CONNECTOR OF THE INJECTION PRESSURE REGULATOR (IPR) VALVE ON THE ENGINE CAN FILL WITH RAIN WATER AND ROAD DEBRIS, POSSIBLY CAUSING TERMINAL CORROSION THAT MAY LEAD TO ELECTRICAL VOLTAGE DROPS.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
0Fires
0Injuries
0Deaths
Across 1 complaints. Severity Index 0.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Electrical System — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Other model years
2006
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.