2025 International Mv Recalls & Complaints

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a silicone black jumper harness, free of charge. Owner notification letters are expected to be mailed December 15, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25509. Vehicles previously repaired under 23V397 will need to have the new remedy completed.

International Motors, LLC (International) is recalling certain 2018 International 4000 Series 4300, 2017-2025 MV, 2018-2024 1300 FBC, 2018-2025 IC Bus TC, and 2024-2025 IC Bus CECB vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Dealers will install plastic saddles onto the positive interconnect cable and as necessary, install wind laces and a J-bolt between each battery, free of charge. Owner notification letters are expected to be mailed September 14, 2026. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 26510. This recall replaces and expands NHTSA Recall 25V534. Vehicles previously repaired under 25V534 will need the new remedy completed.

International Motors, LLC (International) is recalling certain 2021, 2023-2027 MV, and 2026-2027 HV vehicles. The battery interconnect cable may contact the auxiliary stud and hold down bracket, causing a short circuit.

Dealers will inspect and replace the defective gears, free of charge. Owner notification letters were mailed September 30, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 24503.

Navistar, Inc. (Navistar) is recalling certain 2024 International HX, LT, RH and 2024-2025 International HV, MV trucks and 2024 IC Bus CE commercial buses. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.

Dealers will replace the steering gears, free of charge. Owner notification letters were mailed September 30, 2024. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 24505.

Navistar, Inc. (Navistar) is recalling certain 2025 International HV, HX, LT, and MV vehicles. The steering gear sector shaft may have been improperly heat-treated, which can cause the gear teeth to crack or fracture.

Dealers will replace the tie rod ends and realign the front axle, free of charge. Owner notification letters were mailed July 29, 2024. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 24509.

Navistar, Inc. (Navistar) is recalling certain 2025 International HV, LT, MV, and RH trucks. Tie rod assemblies may contain ball studs that may have been incorrectly heat-treated, which can cause them to break, and possibly result in tie rod failure.

Dealers will replace the tie rod end and re-align the front axle, free of charge. Owner notification letters were mailed September 9, 2024. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 24511.

Navistar, Inc. (Navistar) is recalling certain 2025 International HV, HX, LT, MV, and RH vehicles. The tie rod assemblies may contain ball studs that have been incorrectly heat-treated, which can cause them to break, and possibly result in tie rod failure.

International will work with Bendix to reprogram the ECU software, free of charge. Owner notification letters were mailed December 16, 2024. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 24515.

International Motors, LLC (International) is recalling certain 2021-2024 Lonestar, 2021-2025 RH, HV, MV, LT, HX, and 2022 PROSTAR vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.

Dealers will switch the left and right rear air disc brake calipers, replace the rear brake torque plates, and replace the brake pads, free of charge. Owner notification letters were mailed May 12, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25501.

International Motors, LLC (International) is recalling certain 2024 HV, 2020-2025 MV, and 2019 Workstar 7400 trucks. The caliper may contact a suspension spring or axle U-bolt and prevent the outer brake pad from functioning.

Dealers will replace the wiper module, free of charge. Owner notification letters were mailed June 2, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25505.

International Motors, LLC (International) is recalling certain 2025-2026 HV, HX, LT, MV, RH, and 2025 EMV vehicles. The linkage that connects the right-side wiper arm to the motor may separate, causing the wipers to fail.

International will work with Bendix to reprogram the ECU, free of charge. Owner notification letters were mailed January 19, 2026. Owners may contact International's customer service at 1-800-448-7825. International's number for this recall is 25525. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 12, 2026.

International Motors, LLC (International) is recalling certain 2016 7600, 2016-2023 Lonestar, 2018 8600, 2018-2023 LT, 2021-2026 MV, 2022-2023 RH, 2023-2026 HX, and 2025-2026 HV vehicles. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.