IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE.
Remedy & full details
KME IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR KME AT 1-800-235-3928.
KOVATCH (KME) IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 PREDATOR PUMPER FIRE TRUCKS AND 2011 5500 RESCUE FIRE TRUCKS MANUFACTURED FROM APRIL 2010 THROUGH MARCH 2011, EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
Serious20V341000
Service Brakes
retarder that separates from the vehicle may raises the risk of a crash.
Remedy & full details
KME will notify owners, and dealers will inspect the mounting hardware on axial retarders and replace any incorrect hardware, free of charge. This recall is expected to begin July 2020. Owners may contact KME customer service at 1-800-678-1910.
Kovatch Mobile Equipment Corp. (KME) is recalling certain 2011 and 2013-2020 Predator Severe Service, 2015 Predator Panther, 2011, 2013-2014 and 2017-2018 Predator, and 2014 KME commercial cab/chassis firetrucks equipped with optional Telma induction braking systems. The Telma axial retarder braking mechanism may separate from the vehicle while it is moving.
Serious12V253000
Electronic Stability Control (Esc)
THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, raises the risk of A CRASH.
Remedy & full details
KME WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEW ESC MODULE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2012. OWNERS MAY CONTACT KME AT 1-570-669-5154.
KOVATCH MOBILE EQUIPMENT CORPORATION (KME) IS RECALLING CERTAIN 2010-2011 PREDATOR, PREDATOR SS, PREDATOR PANTHER, AND PREDATOR XL EMERGENCY VEHICLES MANUFACTURED FROM MARCH 1, 2010 THROUGH OCTOBER 10, 2011, EQUIPPED WITH FEATURE CODE 04AZX MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) UNITS. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
Serious13V187000
Steering
sudden loss of steering control may raises the risk of a crash.
Remedy & full details
Kovatch will notify owners and dealers will remove the grease fitting, free of charge. The safety recall began on May 20, 2013. Owners may contact Kovatch at 1-570-669-5173. Kovatch's recall campaign number is 2013-E01.
Kovatch Mobile Equipment Corp. (Kovatch) is recalling certain model year 2009-2013 Predator, Predator SS, Panther; 2010-2011 ARFF; and model year 2010-2013 Panther II emergency vehicles. The grease fitting in the steering column shaft may get caught in the column cover. The grease fitting could tear the cover which will impact the driver's ability to steer the vehicle.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
0Fires
0Injuries
0Deaths
Across 1 complaints. Severity Index 0.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Structure:Body — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.