2008 Pierce Impel Recalls & Complaints

A NEW AND IMPROVED LATCH DESIGN HAS BEEN DEVELOPED AND A NEW HOSE BOX INCORPORATING THE NEW LATCH WILL BE INSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 4, 2010. OWNER MAY CONTACT PIERCE AT 1-920-832-3000.

PIERCE IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2009 CUSTOM CONTENDER, DASH, ENFORCER, IMPEL, LANCE SABER, AND VELOCITY FIRE TRUCKS MANUFACTURED FROM FEBRUARY 20, 2003, THROUGH MARCH 27, 2009. THESE TRUCKS MAY BE EQUIPPED WITH DROP-DOWN FIRE HOSE TRAYS MOUNTED UNDER THE FRONT BUMPER. THE HOSE TRAY LATCH MAY ACCIDENTALLY OPEN WHILE THE VEHICLE IS IN MOTION.

PIERCE IS WORKING WITH CUMMINS TO REPAIR THE ENGINES. CUMMINS IS CONDUCTING THIS CAMPAIGN AND WILL PROVIDE THE REMEDY FREE OF CHARGE. PLEASE SEE CUMMINS RECALL CAMPAIGN 09E-046. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2009. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS (1-800-343-7357) OR PIERCE AT 1-920-832-3000.

PIERCE IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 FIRE TRUCKS MANUFACTURED BETWEEN APRIL 1, 2008 AND SEPTEMBER 30, 2009, EQUIPPED WITH CUMMINS ISB CM2150, ISC CM2150, ISL CM2150, ISM CM876, AND ISX CM871 MODEL DIESEL ENGINES. THE VEHICLES MAY BE DESIGNED WITH A HARD WIRED, DASH-MOUNTED SWITCH THAT ENABLES THE VEHICLE OPERATOR TO INHIBIT AFTERTREATMENT DIESEL PARTICULATE FILTER REGENERATION IN ENVIRONMENTS WHERE THE OPERATOR BELIEVES IT MAY BE UNSAFE FOR ELEVATED EXHAUST TEMPERATURES. DUE TO AN ISSUE WITH THE LOGIC IN THE ECM SOFTWARE IN THESE ENGINES, THE SWITCH MAY NOT FUNCTION CORRECTLY, LEADING THE OPERATOR TO BELIEVE THAT THE SWITCH IS IN "INHIBIT" MODE WHEN IT IS NOT.

OWNERS WILL RECEIVE A REMEDY KIT ALONG WITH INSTRUCTIONS AND SHOULD INSPECT THE POSITIVE BATTERY POSTS TO MAKE SURE THE PROTECTIVE CAPS HAVE NOT WORN AWAY, IF CONTACT WITH THE CAB HAS OCCURRED, REPLACE THE BATTERY POST PROTECTIVE CAPS. THIS REMEDY WILL BE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 6, 2009. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.

PIERCE IS RECALLING 167 MY 2007-2008 VELOCITY AND IMPEL FIRE TRUCKS. A BATTERY BOX IS POSITIONED ON BOTH SIDES OF THE CHASSIS FRAME DIRECTLY UNDER THE CAB. CAB INTERFERENCE MAY OCCUR WITH THE POSITIVE BATTERY POST AND THE ALUMINUM CAB FLOOR SUBSTRUCTURE.

THESE VEHICLES HAVE BEEN REPAIRED. NO FURTHER ACTION IS NECESSARY ON THIS RECALL.

PIERCE RECALLED 2 MY 2008 IMPEL FIRE TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.

Pierce will notify owners, and dealers will reprogram the aerial control module, free of charge. The recall began February 28, 2019. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B295.

Pierce Manufacturing (Pierce) is recalling certain 2004-2018 Arrow XT, Dash, Enforcer, Impel, Quantum and Velocity aerial vehicles. The aerial device may unexpectedly rotate to the right when the ladder is being extended.

Pierce will notify owners, and dealers will replace the inner door handles, free of charge. The recall began during May 2013. Owners may contact Pierce at 1-920-832-3000.

Pierce is recalling certain model year 2007-2010 Velocity and Impel fire trucks manufactured from June 6, 2007, through October 30, 2010. The springs inside the inner door handles may allow the door to open inadvertently.

Pierce will notify owners, and dealers will replace the door handle spring with a stiffer one, free of charge. Owners may contact Pierce at 1-920-832-3000. The recall began on June 28, 2013. Pierce's recall number is 74B242.

Pierce Manufacturing Inc. (Pierce) is recalling certain model year 2007-2013 Velocity, Impel, and Dash CF emergency vehicles manufactured June 6, 2007, through May 31, 2013. The springs in the outer door handles are not of sufficient stiffness to prevent inadvertent door opening in certain impacts. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 206, "Door Locks and Door Retention Components."

DEALERS WILL ADJUST THE BOLT SLEEVE AND THE PROPER COMPONENTS FREE OF CHARGE. ALL OWNERS HAVE BEEN NOTIFIED BY ARVINMERITOR.

PIERCE IS RECALLING 15 MY 2007-2008 DASH, ENFORCER, IMPEL, QUANTUM AND VELOCITY FIRE TRUCKS EQUIPPED WITH ARVINMERITOR REAR DISC BRAKES AND HENDRICKSON FIREMAAX SUSPENSION. INTERFERENCE WITH THE BRAKE CALIPER ADJUSTER BOLT SLEEVE AND THE SUSPENSION BEAM MAY OCCUR. THIS INTERFERENCE MAY OCCUR IF THE RIGHT HAND AND LEFT HAND BRAKE COMPONENTS WERE ASSEMBLED ON THE WRONG SIDE OF THE AXLE. THE ADJUSTER BOLT IS DESIGNED TO ROTATE AS THE BRAKE PADS WEAR. IF THE SLEEVE BECOMES DAMAGED, THE SLEEVE MAY PREVENT THE ADJUSTER FROM ROTATING.

PIERCE WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT PIERCE CUSTOMER SERVICE TOLL-FREE AT 1-888-974-3723.

PIERCE MANUFACTURING IS RECALLING 257 MY 2008 EMERGENCY VEHICLES MANUFACTURED BETWEEN JUNE 1 AND OCTOBER 31, 2008, EQUIPPED WITH TRIMARK DOOR LATCHES. THESE LATCHES FAIL TO COMPLY WITH THE TRANSVERSE PULL STATIC LOAD REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." THE LATCHES MAY "POP" INTO THE SECONDARY LOCKING POSITION.

PIERCE WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 31, 2009. OWNERS MAY CONTACT PIERCE TOLL-FREE AT 1-888-974-3723.

PIERCE IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 FIRE TRUCKS EQUIPPED WITH SIDE-ROLL PROTECTION SYSTEMS. THE SENSOR DESIGNED TO DETECT VEHICLE ROLL CAN MALFUNCTION RESULTING IN AN INADVERTENT DEPLOYMENT OF THE PROTECTION SYSTEM.

PIERCE IS WORKING WITH MERITOR WABCO AND WILL REPLACE THE CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT MERITOR WABCO AT 1-248-435-8001 OR PIERCE AT 1-920-832-3000.

PIERCE MANUFACTURING (PIERCE) IS RECALLING CERTAIN MODEL YEAR 2007-2011 ARROW XTAND VELOCITY, MODEL YEAR 2008-2011 CUSTOM CONTENDER, IMPEL, QUANTUM AND MODEL YEAR 2009-2011 SABER EMERGENCY TRUCKS, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM DECEMBER 19, 2007, THROUGH OCTOBER 7, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

DEALERS WILL INSTALL NEW AUTOMATIC TIRE CHAIN BRACKETS. THE NEW BRACKETS PROVIDE ADDITIONAL CLEARANCE FOR THE FULL ACTUATION OF THE DISC BRAKE CALIPERS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN IN JULY 2010. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

PIERCE IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ARROW XT, DASH, ENFORCER, IMPEL, QUANTUM, AND VELOCITY FIRE TRUCKS MANUFACTURED FROM OCTOBER 11, 2006 THROUGH JUNE 16, 2010 AND EQUIPPED WITH MERITOR WABCO EX225 REAR DISC BRAKES AND ONSPOT AUTOMATIC TIRE CHAINS. THE MERITOR WABCO EX225 REAR DISC BRAKE CALIPER MAY INTERFERE WITH THE ONSPOT AUTOMATIC TIRE CHAIN BRACKETS. THIS INTERFERENCE MAY RESTRICT THE CALIPER FROM FULL MOVEMENT.

PIERCE WILL NOTIFY OWNERS AND DEALERS WILL INSTALL A NEW STEERING GEAR MOUNTING BRACKET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 12, 2010. OWNERS ARE BEING INSTRUCTED TO INSPECT THE STEERING GEAR BRACKET PRIOR TO EACH TRIP. THE REMEDY TO REPAIR THIS DEFECT IS EXPECTED TO BEGIN NO EARLIER THE JANUARY 31, 2011. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.

PIERCE IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2008 ARROW XT, LANCE, VELOCITY, ENFORCER, IMPEL, AND DASH CUSTOM FIRE APPARATUS VEHICLES MANUFACTURED FROM MAY 30, 1998 THROUGH NOVEMBER 25, 2008. THE STEERING GEAR BRACKET MAY FRACTURE AND BREAK. IF THIS OCCURS THE STEERING GEAR MAY DETACH FROM THE VEHICLE.

PIERCE WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 2, 2009. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

PIERCE IS RECALLING 185 MODEL YEAR 2008 AND 2009 CUSTOM FIRE TRUCKS MANUFACTURED BETWEEN JANUARY 1, 2008 AND MAY 31, 2009, EQUIPPED WITH MERITOR WABCO STEERING ANGLE SENSORS (SAS). INTERNAL FRICTION CAN DEVELOP BETWEEN THE SENSOR GEARS AND THE SENSOR HOUSING AS A RESULT OF EXTERNAL FORCES EXPERIENCED ON THE VEHICLE INCLUDING VIBRATION. IF DEVELOPED FRICTION IS GREAT ENOUGH, THE DRIVING TAB OF THE SAS CAN SHEAR AS THE DRIVER TURNS THE STEERING WHEEL.

Pierce will notify owners, and dealers will install additional hardware to mount the limited retraction bracket, free of charge. The recall began on August 22, 2018. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B290.

Pierce Manufacturing (Pierce) is recalling certain 2007-2017 Pierce Velocity, Impel, Arrow-XT, Quantum, and Enforcer emergency response vehicles equipped with 75ft aerial devices with a 21 inch or 28 inch limited retraction bracket. The bracket on the aerial device may detach from the aerial and fall to the ground.