RecallRadar

Home → Pontiac → Grand Am → 2004

2004 Pontiac Grand Am Recalls & Complaints

4

open safety recalls on record

Critical

402 owner complaints filed · Severity Index 0.51 · updated 2026-08-07

The recalls

Critical07E021000

Fuel System, Other:Storage:Tank Assembly:Pressure Relief Devices

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy & full details

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Critical04V301000

Fuel System, Gasoline:Storage

FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy & full details

DEALERS WILL INSPECT THE FUEL TANK, AND REPLACE IT, IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A FUEL TANK THAT DOES NOT MEET SPECIFICATION. A WELD ON THESE FUEL TANKS MAY BE INSUFFICIENT, RESULTING IN A FUEL LEAK.

Serious14V400000

Electrical System:Ignition

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, raises the risk of injury.

Remedy & full details

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Serious09E012000

Exterior Lighting

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy & full details

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Complaint volume

402 this model-year 6 median, same year

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

What owners reported happened

34Crashes
10Fires
24Injuries
1Deaths

Across 402 complaints. Severity Index 0.51.

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

Electrical System112 · 28%Exterior Lighting30 · 7%Engine17 · 4%Air Bags16 · 4%Vehicle Speed Control13 · 3%Steering12 · 3%Electrical System · Ignit…12 · 3%Structure11 · 3%
  1. Electrical System — 112 reports
  2. Exterior Lighting — 30 reports
  3. Engine — 17 reports
  4. Air Bags — 16 reports
  5. Vehicle Speed Control — 13 reports
  6. Steering — 12 reports
  7. Electrical System:Ignition:Anti-Theft:Control Module — 12 reports
  8. Structure — 11 reports
  9. Exterior Lighting:Turn Signal — 9 reports
  10. Unknown Or Other — 9 reports

What to do

  1. Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
  2. Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
  3. Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

1995 (1) · 1996 (6) · 1997 (4) · 1998 (3) · 1999 (6) · 2000 (8) · 2001 (7) · 2002 (4) · 2003 (5) · 2004 · 2005 (4)

Numbers in brackets are open recall campaigns for that year.

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit
Is that tyre actually right for your car?
2,808 fitment guides
FuelFacts
What that trip really costs in fuel
Live consumption data
CostCompare
What things cost, city by city
2,123 comparisons