RecallRadar

Home → Pontiac → Sunfire → 2003

2003 Pontiac Sunfire Recalls & Complaints

2

open safety recalls on record

Serious

113 owner complaints filed · Severity Index 0.33 · updated 2026-08-07

The recalls

Serious08E063000

Steering

IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy & full details

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Serious04V524000

Exterior Lighting:Turn Signal

INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES.

Remedy & full details

DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, THE CRUISE CONTROL WOULD NOT ENGAGE.

Complaint volume

113 this model-year 8 median, same year

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

What owners reported happened

7Crashes
1Fires
5Injuries
0Deaths

Across 113 complaints. Severity Index 0.33.

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

Electrical System16 · 14%Exterior Lighting8 · 7%Exterior Lighting · Turn …7 · 6%Service Brakes, Hydraulic…5 · 4%Engine And Engine Cooling…4 · 4%Exterior Lighting · Headl…4 · 4%Air Bags4 · 4%Exterior Lighting · Turn …3 · 3%
  1. Electrical System — 16 reports
  2. Exterior Lighting — 8 reports
  3. Exterior Lighting:Turn Signal — 7 reports
  4. Service Brakes, Hydraulic:Foundation Components:Disc:Rotor — 5 reports
  5. Engine And Engine Cooling:Engine — 4 reports
  6. Exterior Lighting:Headlights — 4 reports
  7. Air Bags — 4 reports
  8. Exterior Lighting:Turn Signal:Flasher Unit — 3 reports
  9. Electrical System:Wiring — 3 reports
  10. Exterior Lighting:Brake Lights — 2 reports

What to do

  1. Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
  2. Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
  3. Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

1995 (7) · 1996 (10) · 1997 (9) · 1998 (7) · 1999 (5) · 2000 (3) · 2001 (3) · 2002 (2) · 2003 · 2004 (2) · 2005 (1)

Numbers in brackets are open recall campaigns for that year.

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit
Is that tyre actually right for your car?
2,808 fitment guides
FuelFacts
What that trip really costs in fuel
Live consumption data
CostCompare
What things cost, city by city
2,123 comparisons