How many recalls does the 2005 Scion Tc have?

4 open NHTSA safety recalls are on record for the 2005 Scion Tc, alongside 203 owner complaints.

Home → Scion → Tc → 2005

2005 Scion Tc Recalls & Complaints

open safety recalls on record

Serious

203 owner complaints filed · Severity Index 1.33 · updated 2026-08-07

The recalls

Serious06V096000

Air Bags

THIS MAY raises the risk of INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Remedy & full details

DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Serious06V408000

Air Bags:Side/Window

IF THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS INADVERTENTLY DEPLOY, THEY COULD CAUSE PERSONAL INJURY IF AN OCCUPANT IS SEATED ON THE SAME SIDE OF THE VEHICLE AS THE DOOR THAT IS CLOSED WITH A HIGH RATE OF FORCE.

Remedy & full details

DEALERS WILL REPLACE THE TWO SIDE IMPACT AIRBAG SENSORS AND INSTALL A URETHANE PAD IN THE FRONT DOORS, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-866-548-1851.

ON CERTAIN VEHICLES, THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS MAY INADVERTENTLY DEPLOY. THIS CONDITION CAN OCCUR IF THE DOOR FOR THAT SIDE OF THE VEHICLE IS CLOSED WITH A HIGH RATE OF FORCE WHILE THE VEHICLE'S IGNITION IS IN THE "ON" POSITION OR WITHIN 90 SECONDS OF TURNING THE IGNITION KEY FROM THE "ON" POSITION TO THE "OFF" POSITION.

Serious05V483000

Visibility:Sun/Moon Roof Assembly

PIECES OF THE WIND DEFLECTOR GLASS MAY SEPARATE FROM THE FRAME AND FALL UPON THE VEHICLE OCCUPANTS CAUSING DRIVER DISTRACTION AND/OR INJURY.

Remedy & full details

DEALERS WILL INSTALL A PROTECTIVE LAMINATE TO THE WIND DEFLECTOR TO PREVENT PIECES OF GLASS FROM SEPARATING FROM THE WIND DEFLECTOR FRAME. THE RECALL BEGAN OCTOBER 27, 2005. OWNERS MAY CONTACT TOYOTA AT 1-866-707-2466.

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A GLASS WIND DEFLECTOR, THE DEFLECTOR, IF IMPACTED BY A PROJECTILE, SUCH AS ROAD DEBRIS, WHILE DRIVING WITH THE WIND DEFLECTOR IN THE UPWARD-TILTED POSITION AT HIGHWAYS SPEEDS, MAY SHATTER AND SEPARATE FROM THE FRAME.

Moderate10V035000

Equipment:Other:Labels

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy & full details

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Complaint volume

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

What owners reported happened

34Crashes

4Fires

40Injuries

3Deaths

Across 203 complaints. Severity Index 1.33.

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

Visibility:Sun/Moon Roof Assembly — 32 reports
Structure:Body — 15 reports
Air Bags — 15 reports
Unknown Or Other — 11 reports
Engine — 9 reports
Vehicle Speed Control — 7 reports
Visibility — 7 reports
Tires — 7 reports
Structure — 6 reports
Visibility:Windshield — 5 reports

What to do

Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

2005 · 2006 (5) · 2007 (2) · 2008 (3) · 2009 (3) · 2010 (2) · 2011 (1) · 2012 (2) · 2013 (1) · 2014 (1) · 2015 (3) · 2016 (3)

Numbers in brackets are open recall campaigns for that year.

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit

Is that tyre actually right for your car?

2,808 fitment guides

FuelFacts

What that trip really costs in fuel

Live consumption data

CostCompare

What things cost, city by city

2,123 comparisons