REPROGRAMMING THE ECM WILL PREVENT THE POTENTIAL OF A TURBOCHARGER FAILURE FROM PROGRESSING TO AN ENGINE COMPARTMENT FIRE.
Remedy & full details
DETROIT DIESEL IS CONDUCTING THIS RECALL (PLEASE SEE 06E019000) AND WILL REPROGRAM THE ECM TO CURRENT MAINFRAME CALIBRATIONS FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR SETRA AT 905-403-7807.
ON CERTAIN MOTOR COACHES EQUIPPED WITH DETROIT DIESEL SERIES C-60 ENGINES, THE ELECTRONIC CONTROL MODULE (ECM) WILL REQUIRE TO BE REPROGRAMMED TO CURRENT MAINFRAME CALIBRATIONS.
Critical07V198000
Electrical System:Wiring
THIS COULD LEAD TO A SHORT CIRCUIT AND POSSIBLY A SUBSEQUENT FIRE.
Remedy & full details
DEALERS WILL CHECK THE WIRING HARNESS ROUTING AND WILL CHANGE THE DAMAGED WIRES. IN ADDITION THE WIRING HARNESS WILL BE RELOCATED IN SUCH A WAY AS TO PREVENT RUBBING. THE RECALL BEGAN ON MAY 18, 2007. OWNERS MAY CONTACT SETRA AT 1-800-882-8054.
ON CERTAIN MOTOR COACHES, THE ELECTRICAL WIRING HARNESS LOCATED BEHIND THE REAR TOILET WAS NOT PROPERLY INSTALLED. AS A RESULT, RUBBING CAN OCCUR ON THE OUTSIDE WIRE INSULATION CAUSING THE INSULATION TO WEAR AWAY AND EVENTUALLY CAUSE SUBSEQUENT ARCING.
Critical07V193000
Electrical System
IF THE OPEN WIRE ENDS COME INTO CONTACT WITH PARTS OF THE FRAME, IT MAY BE POSSIBLE FOR A SHORT CIRCUIT TO OCCUR AND THEN A SUBSEQUENT FIRE.
Remedy & full details
DEALERS WILL SEND OUT TECHNICIANS TO DISCONNECT THE POWER TO THE WIRES AND REROUTE THE WIRES PROPERLY FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2007. OWNERS MAY CONTACT SETRA AT 1-800-882-8054.
ON CERTAIN MOTOR COACHES, THE ELECTRICAL WIRE PREPARATION FOR THE CONTROL OF SOLAR ROOF HATCHES WAS NOT CARRIED OUT PROPERLY. THIS WIRING MAY CONTAIN OPEN ENERGIZED WIRE ENDS LOCATED IN THE HARNESS.
Serious16V142000
Suspension:Front:Control Arm
Should the tube crack and separate from the shaft of the vehicle, loss of vehicle control is possible, raises the risk of a crash.
Remedy & full details
MCI, the sales agent for these vehicles, notified owners verbally, and dealers will replace the lower control arms, free of charge. The recall began on March 28, 2016. Owners may contact Setra customer service at 1-800-241-2947. Setra's number for this recall is 33.10U10124B.
Setra of North America (Setra) is recalling certain model year 2005-2009 S417 coaches manufactured March 1, 2005, to February 28, 2009, that had service part lower control arm(s) installed. The hot crimping that connects the tube ends to the control arm joint housing shafts may crack, causing the tube to separate from the shaft.
Serious09V044000
Equipment:Other:Labels
IN THE EVENT OF A CRASH, WITHOUT THE CORRECT INSTRUCTIONS A PASSENGER MAY NOT KNOW HOW TO UNLATCH AND OPEN THE EMERGENCY EXIT raises the risk of INJURY.
Remedy & full details
DEALERS WILL SEND LABELS WITH A SERVICE INSTRUCTIONS EXPLAINING THE LOCATION OF THE LABELS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MARCH 2009. OWNERS MAY CONTACT SETRA AT 1-800-882-8054.
SETRA IS RECALLING 490 MY 1984-2001 S215, MY 1994-2002 S217 AND MY 2003-2009 S417 MOTOR COACHES EQUIPPED WITH EMERGENCY EXITS. THESE MOTOR COACHES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." WHEN A RELEASE MECHANISM IS NOT LOCATED WITHIN AN OCCUPANT SPACE OF AN ADJACENT SEAT, A LABEL MEETING THE REQUIREMENTS OF S5.5.2 THAT INDICATES THE LOCATION OF THE NEAREST RELEASE MECHANISM SHALL BE PLACED WITHIN THE OCCUPANT SPACE. EXAMPLE: "EMERGENCY EXIT INSTRUCTIONS LOCATED NEXT TO SEAT AHEAD" THESE LABELS ARE NOT INSTALLED IN THE MOTOR COACHES MENTIONED IN THE EXAMPLE ABOVE.
Serious05V229000
Parking Brake:Indicator Light
THE DRIVER MAY MISINTERPRET THE SIGNAL AND WRONGLY ASSUME THE PARKING BRAKE IS ENGAGED.
Remedy & full details
DEALERS WILL REPLACE THE PARKING BRAKE PRESSURE SWITCH FREE OF CHARGE. THE RECALL ON MAY 24, 2005. OWNERS MAY CONTRACT SETRA AT 1-800-882-8054.
ON CERTAIN 36-58 PASSENGER MOTOR COACHES, THE PARKING BRAKE INDICATOR LIGHT ON THE DASHBOARD MAY ILLUMINATE IN LIMITED CIRCUMSTANCES EVEN THOUGH THE PARKING BRAKE IS NOT ENGAGED.
Moderate11V220000
Visibility:Glass, Side/Rear
COMPLIANCE TO FMVSS 205 IS REQUIRED FOR ANY AND ALL VEHICLES IN THE UNITED STATES TO ASSURE MINIMUM SAFETY REQUIREMENTS.
Remedy & full details
DEALERS WILL REPLACE THE PARTITION GLASS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED BEGIN DURING MAY 2011. OWNERS MAY CONTACT SETRA AT 1-800-882-8054.
SETRA IS RECALLING CERTAIN MODEL YEAR 2003-2010 S417 AND MODEL YEAR 2011 S417 TC MOTOR COACHES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS." THE PARTITION GLASS BEHIND THE DRIVER OF EACH AFFECTED BUS DOES NOT HAVE THE NECESSARY DOT MARKINGS AS SPECIFIED AND WAS NOT MARKED CORRECTLY.
Moderate05V228000
Parking Brake:Indicator Light
ILLUMINATION IN RED IS REQUIRED BY THE APPLICABLE STANDARD.
Remedy & full details
DEALERS WILL INSTALL APPROPRIATE SOFTWARE TO CHANGE THE COLOR OF THE PARKING BRAKE INDICATOR LAMP FROM GREEN TO RED FREE OF CHARGE. THE RECALL BEGAN ON MAY 24, 2005. OWNERS MAY CONTACT SETRA AT 1-800-882-8054.
CERTAIN (36-58 PASSENGER) MOTOR COACHES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, "CONTROLS AND DISPLAYS." THE PARKING BRAKE INDICATOR LAMP ILLUMINATES IN GREEN AND NOT RED, WHEN THE PARKING BRAKE IS ENGAGED.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
1Fires
0Injuries
0Deaths
Across 1 complaints. Severity Index 3.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Suspension:Rear — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.