SHORT CIRCUIT AND ELECTRICAL ARCING COULD LEAD TO A FIRE IN THE RIGHT FRONT HEADLAMP AREA.
Remedy & full details
TESLA MOTORS WILL CHECK THE ROUTING OF THE 12V AUXILIARY CABLE AND INSTALL A PROTECTIVE SLEEVE OVER THE WIRE FREE OF CHARGE. THIS WILL PREVENT MISROUTING AND PINCHING BY THE WHEEL WELL COVER. THE SAFETY RECALL BEGAN ON OCTOBER 31, 2010. OWNERS MAY CONTACT TESLA CUSTOMER SERVICE AT 877-888-3752.
TESLA IS RECALLING CERTAIN MODEL YEAR 2010 ROADSTER 2.0 AND 2.5 VEHICLES EQUIPPED WITH A 12V AUXILIARY CABLE. THE 12V AUXILIARY CABLE FOR THE LOW VOLTAGE BACK UP POWER SYSTEM MAY BE IMPROPERLY ROUTED. IF THE WIRE IS IMPROPERLY ROUTED, AND TRAPPED AGAINST THE WHEEL WELL COVER, THE WIRE MAY ABRADE AGAINST THE EDGE OF THE CARBON FIBER ARMATURE AND, OVER TIME, EXPOSE THE WIRE. CONTACT BETWEEN THE BARE WIRE AND CARBON FIBER MAY CAUSE A SHORT-CIRCUIT LEADING TO POSSIBLE ELECTRICAL ARCHING.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
0Fires
0Injuries
0Deaths
Across 2 complaints. Severity Index 0.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Power Train — 1 reports
Electrical System — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Other model years
2010
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.