2009 Thomas Built Buses Saf-T-Liner C2 Recalls & Complaints

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DETROIT DIESEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 25, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712. THIS SAFETY RECALL CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 10V-468).

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 THOMAS BUILT SAF-T-LINER C2 AND SAF-T-LINER HDX SCHOOL BUSES AND FCCC B2 BUS CHASSIS USED IN SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM AUGUST 18, 2006, THROUGH JULY 7, 2010, EQUIPPED WITH EPA 2007 MBE 900 DETROIT DIESEL ENGINES. ENGINE SOFTWARE MAY NOT REACT PROPERLY TO CERTAIN AFTERMARKET TREATMENT DEVICE FAULT CODES. THE SOFTWARE MAY UNNECESSARILY SHUTDOWN A VEHICLE OR MAY FAIL TO SHUTDOWN A VEHICLE WITH AN AFTERMARKET DEVICE OVER-TEMP FAULT.

DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DETROIT DIESEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 SAF-T-LINER C2 AND SAF-T-LINER HDX SCHOOL BUSES MANUFACTURED FROM OCTOBER 5, 2006 THROUGH MAY 24, 2010, EQUIPPED WITH EPA 2007 MBE 900 DETROIT DIESEL ENGINES. ENGINE SOFTWARE MAY NOT REACT PROPERLY TO CERTAIN AFTERMARKET TREATMENT DEVICE FAULT CODES. THE SOFTWARE MAY UNNECESSARILY SHUTDOWN A VEHICLE OR MAY FAIL TO SHUTDOWN A VEHICLE WITH AN AFTERMARKET DEVICE OVER-TEMP FAULT.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FCCC B2 106 CH AND THOMAS BUILT SAF-T-LINER C2 AND HDX SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 5, 2006 THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.

DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

DTNA WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 SAF-T-LINER EF, MINOTOUR, SAF-T-LINER C2, SAF-T-LINER HDX TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 23, 2010. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 SCHOOL AND NON-SCHOOL BUSES MANUFACTURED FROM MAY 10, 2007 THROUGH AUGUST 31, 2009, EQUIPPED WITH AG2 ENTRANCE DOORS. THE ENTRANCE DOOR GLASS MAY BE INADEQUATELY BONDED TO THE DOOR FRAME AND MAY SEPARATE FROM THE VEHICLE.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE PRESSURE SWITCH FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 18, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR THOMAS BUILT BUSES AT 1-336-889-4871.

DAIMLER TRUCKS IS RECALLING 15,686 MY 2005 THROUGH 2009 FCCC AND THOMAS BUILT SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN MARCH 2005 AND MAY 2008 EQUIPPED WITH A CERTAIN BRAKE LAMP AIR PRESSURE SWITCH. THE CONTACTS IN THE PRESSURE SWITCH FOR THE LOW CURRENT BRAKE LAMP SIGNAL TO THE CHASSIS ECU MAY HAVE BECOME CONTAMINATED BY SILICONE DURING ASSEMBLY CAUSING INSULATING DEPOSITS TO BUILD UP OVER TIME PREVENTING THE BRAKE LAMPS FROM OPERATING.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS AND DIRECT WARRANTY CUSTOMER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 6, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING 22,206 THOMAS BUILT MY 2005 THROUGH 2010 SCHOOL BUSES MANUFACTURED FROM OCTOBER 2004 THROUGH NOVEMBER 24, 2008. THE LOWER END OF THE FRONT ENTRANCE DOOR AFT ASSIST HANDRAIL MAY BE LOCATED TOO CLOSE TO THE STEP.

DTNA WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 SAF-T-LINER EF, MINOTOUR, SAF-T-LINER C2, AND SAF-T-LINER HDX SCHOOL BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

DTNA WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLES TO ENSURE THAT THERE IS THE CORRECT CLEARANCE BETWEEN THE FUEL AND BRAKE LINES. DAMAGED LINES WILL BE REPLACED. REPAIRS WILL BE MADE BY DTNA AUTHORIZED SERVICE FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MARCH 9, 2004, THROUGH JANUARY 2, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES, HYDRAULIC BRAKES, AND A FUEL WATER SEPARATOR. THE FUEL LINE GOING FROM THE FUEL WATER SEPARATOR TO THE ENGINE MAY RUB ON THE HYDRAULIC BRAKE LINES POTENTIALLY RESULTING IN BRAKE FLUID LEAK.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES BUILT ON FCCC B2 CHASSIS MANUFACTURED FROM OCTOBER 15, 2004 THROUGH NOVEMBER 25, 2009, EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.

DAIMLER TRUCKS WILL NOTIFY OWNERS. DEALERS WILL INSPECT THE UNITS AND CLAMPS WITH SHORTER OFFSET THAN SPECIFIED WILL BE REPLACED WITH LONGER OFFSET CLAMPS. ANY BRAKE LINES FOUND TO BE DAMAGED WILL BE REPLACED. REPAIRS WILL BE DONE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 23, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES AND FCCC B2 CHASSIS MANUFACTURED FROM OCTOBER 1, 2007 THROUGH AUGUST 10, 2009, EQUIPPED WITH CUMMINS ISB CM2150 J1939/1587 ENGINE CONTROL UNIT, BOSCH HYDRAULIC PIN-SLIDE FRONT BRAKES, AND WEBASTO 17K BTU COOLANT HEATER. THE FRONT RIGHT HAND CROSSOVER BRAKE LINE MAY HAVE BEEN SECURED USING SHORTER OFFSET THAN SPECIFIED CLAMPS POTENTIALLY ALLOWING THE BRAKE LINE TO RUB ON THE SURROUNDING COMPONENTS. THIS MAY LEAD TO A BRAKE FLUID LEAK.

DEALERS WILL INSPECT AND ADJUST THE FASTENERS AS REQUIRED. DAMAGED FASTENERS WILL BE REPLACED. REPAIRS WILL BE MADE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES AND FCCC B2 CHASSIS MANUFACTURED FROM JUNE 1, 2007 THROUGH SEPTEMBER 28, 2009. FASTENERS USED TO CONNECT THE REAR SUSPENSION SPRING TO THE SUSPENSION HANGER BRACKET MAY NOT HAVE BEEN TORQUED TO SPECIFICATION. UNDER TORQUED FASTENERS MAY BECOME LOOSE AND POTENTIALLY FALL OUT.

DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

DTNA WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 10, 2010. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

DTNA HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MAY 10, 2007, THROUGH JANUARY 8, 2010. THE REED SWITCH USED TO DETECT THE POSITION OF THE AIR OPERATED FRONT ENTRANCE DOOR MAY MALFUNCTION CAUSING WARNING LIGHTS AND THE CROSSING ARM TO OPERATE IMPROPERLY DURING STUDENT LOADING AND UNLOADING.

DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was mailed to owners on August 28, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2004 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 non-school buses. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.

DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim notice was sent to owners on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.

Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 school buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.

DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim letter was mailed on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.

Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 transit buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.

DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. Daimler issued an interim notification to owners on August 25, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2013 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 school buses manufactured from February 5, 2001, through May 29, 2012. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.

DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began onNovember 2, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-686.

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses FS-65, Saf-T-Liner C2, Saf-T-Liner EF, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour DRW school buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.