2003 Thomas Er Recalls & Complaints

THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY REPLACING THE TYPE II AUTO RESET CIRCUIT BREAKERS WITH MANUAL CIRCUIT BREAKERS, AND THE JUMPER CABLE. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT THOMAS BUILT CUSTOMER SUPPORT OFFICE AT 336-889-4871.

CERTAIN 2001 THROUGH 2008 THOMAS BUILT FS-56, ER, MVP ER, HDX, AND MVP EF SCHOOL BUSES MANUFACTURED FROM OCTOBER 23, 2000, THROUGH JANUARY 24, 2006, EQUIPPED WITH TYCO PC BOARD AND TYPE II AUTO RESET CIRCUIT BREAKERS. TYPE II AUTO RESET CIRCUIT BREAKER TEMPERATURES MAY EXCEED THE RATING OF THE TYCO PC BOARD CAUSING THE BOARDS TO MELT POTENTIALLY RESULTING IN A VEHICLE FIRE.

JOHN DEERE WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER/THOMAS BUILT AND WILL UPDATE THE ENGINE CONTROL UNIT SOFTWARE FREE OF CHARGE. OWNERS MAY CONTACT JOHN DEERE AT 1-800-JD-ENGINE.

CERTAIN MY 2002-2005 THOMAS BUILT SAF-T-LINER ER SCHOOL BUSES AND ER TRANSIT BUSES MANUFACTURED BETWEEN NOVEMBER 2002 AND FEBRUARY 2005 AND EQUIPPED WITH JOHN DEERE 8.1L COMPRESSED NATURAL GAS ENGINES MODELS HFN01 AND HFN03. THE ENGINE CONTROL UNIT AND THROTTLE CAN UNEXPECTEDLY SURGE. THESE UNITS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, ACCELERATOR CONTROL SYSTEMS.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.

THOMAS BUILT BUS DEALERS WILL REPLACE THE SOLID STATE DUAL POWER SWITCH WITH A MECHANICAL CIRCUIT PRODUCTION (MEGA FUSE). THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

DAIMLER TRUCKS IS RECALLING 18,198 MY 2003-2009 THOMAS BUILT ER, MVP-ER, HDX, AND MVP-EF SCHOOL AND TRANSIT BUSES EQUIPPED WITH A DUAL POWER SWITCH AND MANUFACTURED FROM FEBRUARY 1, 2002 THROUGH OCTOBER 17, 2008. SOLID STATE CIRCUIT BREAKERS MAY TRIP UNNECESSARILY POTENTIALLY RESULTING IN A LOSS OF POWER TO THE BUS CHASSIS AND BODY ELECTRICAL CIRCUITS CAUSING AN UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING.

FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, THOMAS BUILT IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, DEALERS WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, THOMAS BUILT WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE RECALL BEGAN ON SEPTEMBER 14, 2005. OWNERS MAY CONTACT THOMAS BUILT'S CUSTOMER SUPPORT OFFICE AT 336-889-4871.

CERTAIN 2002-2005 MY THOMAS BUILT MINOTOUR, CONVENTIONAL, MVP-ER, ER, HDX, AND MVP-EF MODEL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 8, 2002, AND MARCH 8, 2005, EQUIPPED WITH SPECIALTY MFG "5" SERIES STOP ARMS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

THOMAS BUILT WILL NOTIFY ITS OWNERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2005. OWNERS MAY CONTACT THOMAS BUILT'S CUSTOMER SUPPORT OFFICE AT 336-889-4871.

CERTAIN 2002-2005 MY THOMAS BUILT MINOTOUR, CONVENTIONAL, MVP-ER, ER, HDX, AND MVP-EF MODEL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 8, 2002, AND MARCH 8, 2005, EQUIPPED WITH SPECIALTY MFG "5" SERIES STOP ARMS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.