VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Critical04V451000
Engine And Engine Cooling:Cooling System:Fan
FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy & full details
DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Serious07E023000
Service Brakes, Hydraulic:Foundation Components:Master Cylinder
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy & full details
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Moderate06V441000
Vehicle Speed Control
THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy & full details
DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Moderate00V238000
Suspension:Front:Control Arm:Upper Ball Joint
THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.
Remedy & full details
DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
21Crashes
11Fires
18Injuries
0Deaths
Across 442 complaints. Severity Index 0.33.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Vehicle Speed Control — 88 reports
Electrical System — 44 reports
Engine And Engine Cooling — 25 reports
Fuel System, Gasoline — 20 reports
Engine And Engine Cooling:Engine — 19 reports
Power Train:Automatic Transmission — 15 reports
Suspension:Front — 11 reports
Air Bags — 9 reports
Engine And Engine Cooling:Engine:Gasoline — 9 reports
Service Brakes, Hydraulic — 9 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.