FAILURE OF THE VALVE IN AN EMPTY OR LIGHTLY LOADED TRAILER WHILE THE VEHICLE IS IN MOTION COULD RESULT IN A HARD APPLICATION OF THE SPRING BRAKES, POSSIBLY LOCKING UP THE TRAILER WHEELS AND RESULTING IN A VEHICLE CRASH.
Remedy & full details
SEALCO WILL PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS TO CUSTOMERS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SEALCO AT 602-253-1007 OR WABASH AT 765-771-5404.
ON CERTAIN TRAILERS EQUIPPED WITH SEALCO SPRING BRAKE CONTROL VALVE ASSEMBLIES INCORPORATED IN ARVINMERITOR AXLES, PART NOS. 110700 AND 110800, THERE IS A RECESSED AREA ON TOP OF THE VALVE IN WHICH A BRASS GUIDE PIN FITS DOWN INSIDE THE BODY OF THE VALVE AND IS HELD IN PLACE BY A STEEL SNAP RING. THE RECESSED AREA ALLOWS ACCUMULATION OF WATER, DIRT, AND/OR CHEMICALS TO BUILD UP BEHIND THE SNAP RING TO THE POINT WHERE IT WILL NO LONGER CONTAIN THE GUIDE PIN RESULTING IN A FAILURE OF THE AIR VALVE.
Moderate00V102002
Suspension
OUTBOARD BEARING FAILURE CAN RESULT IN A SEPARATION OF THE HUB ASSEMBLY FROM THE SPINDLE.
Remedy & full details
CONMET IS CONDUCTING THE OWNER NOTIFICATION FOR THIS CAMPAIGN. AUTHORIZED DEALERS ARE INSTRUCTED TO CONVERT GREASED HUBS TO OIL HUBS IF THE TIRE INFLATION SYSTEM IS TO REMAIN ON THE TRAILER. IF THE TIRE INFLATION SYSTEM IS REMOVED, THE HUB MUST BE INSPECTED FOR CONTAMINATION AND CORROSION. THE HUB AND BEARING ASSEMBLY MUST BE REPLACED IF THERE IS EVIDENCE OF CORROSION. IF THERE IS NO EVIDENCE OF CORROSION, LUBRICANT AND SEAL MAINTENANCE CAN BE PERFORMED AND THE HUB REINSTALLED. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CONSOLIDATED METCO AT 1-800-425-4827 OR WABASH AT 1-765-771-5440.
VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH CONMET PREGREASED TRAILER AXLE HUBS. THE OUTBOARD BEARING ON THE PREGREASED TRAILER AXLE HUBS USED WITH THE TIRE INFLATION SYSTEMS MAY FAIL DUE TO THE INTRUSION OF CONTAMINANTS THROUGH THE TIRE INFLATION SYSTEM.
Moderate00V127002
Service Brakes, Air:Supply:Quick Release Valve
IF FROZEN, THE OPERATOR WILL NOT BE ABLE TO MODULATE THE BRAKE FORCES WITH THE BRAKE PEDAL.
Remedy & full details
BENDIX IS CONDUCTING THE OWNER NOTIFICATION FOR THIS RECALL. OWNERS ARE INSTRUCTED TO CONTACT BENDIX AT 1-800-478-1793 TO RECEIVE A REPLACEMENT UNIT.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH BRAKE VALVES MANUFACTURED BY HONEYWELL BENDIX. THE ORIENTATION AND LOCATION OF THE BRAKE VALVE IS SUCH THAT WATER CAN GET INTO THE VALVE THROUGH A VENT IN THE VALVE. THE WATER WILL CONTAMINATE THE AIR SYSTEM AND COULD FREEZE THE BRAKE VALVE.
Moderate00V093000
Service Brakes, Air
THE BRAKES WILL NOT FUNCTION PROPERLY.
Remedy & full details
THE TRAILER OWNERS (JB HUNT) WILL INSPECT THE AXLE SUSPENSIONS AND CORRECT THE BRAKE CAMSHAFT CONDITION.
VEHICLE DESCRIPTION: TRAILER AXLE SUSPENSIONS INSTALLED ON WABASH NATIONAL TRAILERS WERE ASSEMBLED WITH INCORRECT BRAKE CAMSHAFTS. THESE TRAILERS WILL NOT COMPLY WITH THE DECELERATION OR PARKING REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS."
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
2Fires
0Injuries
0Deaths
Across 3 complaints. Severity Index 2.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Power Train:Driveline:Driveshaft — 1 reports
Power Train:Axle Assembly — 1 reports
Suspension — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.