THE OIL LINE MAY BE CUT ON THE CYLINDER HEAD CAUSING AN OIL LEAK AND A POSSIBLE FIRE.
Remedy & full details
CATERPILLAR, IN CONJUNCTION WITH PACCAR, WILL BE CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN FREE OF CHARGE. OWNERS MAY CALL CATERPILLAR AT 309-675-6496, KENWORTH AT 425-828-5440, OR PETERBILT AT 940-591-4201.
ON CERTAIN TRACTORS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE VARIABLE VALVE ACTUATION OIL LINE MAY WEAR AGAINST THE SHARP EDGE OF THE CYLINDER HEAD IF NOT POSITIONED CORRECTLY.
Serious08V099000
Service Brakes, Air:Slack Adjusters
REDUCTION IN BRAKING CAPACITY COULD raises the risk of A CRASH.
Remedy & full details
DEALERS WILL INSPECT AND REPLACE THE SLACK ADJUSTERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 21, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196.
PACCAR IS RECALLING 130 MY 2005-2007 KENWORTH C500, T800, W900, AND PETERBILT MODELS 357 AND 379 TRACTOR TRAILERS EQUIPPED WITH FABCO SLACK ADJUSTERS ON SISU AXLES. THE SLACK ADJUSTERS MAY FAIL AS A RESULT OF A FATIGUE CRACK RENDERING THE SLACK ADJUSTER INOPERATIVE. THIS COULD REDUCE BRAKING EFFECTIVENESS.
Serious07V090000
Service Brakes, Air
IF STOPPING DISTANCE WAS LIMITED, A VEHICLE CRASH COULD RESULT.
Remedy & full details
DEALERS WILL CONVERT THE SINGLE RELAY VALVE TO A DUAL RELAY VALVE SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MAY 21, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.
CERTAIN TRUCKS FAIL TO COMPLY WITH THE BRAKE TIMING REGULATORY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE BRAKE VALVE WAS MOVED TO THE OPPOSITE RAIL, INCREASING THE LENGTH OF THE AIR LINE, WHICH IN TURN INCREASED THE WHEELBASE REQUIRING A DUAL RELAY VALVE SYSTEM. THE VEHICLES WERE MANUFACTURED WITH A SINGLE VALVE SYSTEM.
Serious06V391000
Power Train:Driveline
THIS MISALIGNMENT CAN CAUSE THE VEHICLE TO LOSE DIRECTIONAL STABILITY AT SPEEDS THAT MAY RESULT IN A VEHICLE CRASH.
Remedy & full details
DEALERS WILL INSPECT THE VEHICLES TO DETERMINE IF THEY WERE MANUFACTURED WITH A SUSPECT TORQUE ROD END. IF A SUSPECT TORQUE ROD END IS FOUND, THE ENTIRE TORQUE ROD WILL BE REPLACED. THE RECALL BEGAN ON OCTOBER 9, 2006. OWNERS MAY CONTACT PETERBILT AT 1-940-591-4196 OR KENWORTH AT 1-425-828-5440.
ON CERTAIN TRUCKS EQUIPPED WITH CHALMERS REAR SUSPENSIONS, THE ADJUSTABLE TORQUE ROD END CASTINGS MAY BE BRITTLE. A BRITTLE ROD END CASTING MAY FRACTURE WITHOUT WARNING, CAUSING THE VEHICLES' REAR AXLES TO BECOME MISALIGNED.
Serious07V107000
Power Train:Automatic Transmission
IF ANY OF THESE CONDITIONS EXISTS, THE TRANSMISSION WILL NOT AUTOMATICALLY SHIFT INTO NEUTRAL WHEN LEFT IN DRIVE WITH THE PARKING BRAKE SET ENGAGED.
Remedy & full details
DEALERS WILL INSPECT THE AFFECTED VEHICLES TO ENSURE THE AUTO NEUTRAL FEATURE FUNCTIONS PROPERLY AND, IF NEEDED, WILL MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.
ON CERTAIN TRUCKS, THE WIRING, PARTS, OR TRANSMISSION PROGRAMMING REQUIRED FOR THE AUTO NEUTRAL FEATURE TO FUNCTION AS DESIGNED WERE EITHER NOT INSTALLED, CONNECTED, OR PROGRAMMED PROPERLY.
Complaint volume
Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.
What owners reported happened
0Crashes
1Fires
0Injuries
0Deaths
Across 1 complaints. Severity Index 3.00.
Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.
What owners report most
Electrical System:Wiring — 1 reports
What to do
Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.
Numbers in brackets are open recall campaigns for that year.
Questions
Does an open recall mean the car is unsafe to drive?
Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.
Do I pay for recall repairs?
No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.
Why are there complaints but no recalls?
Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.
From the same data desk
Independent sites, same maintainer, same open-data standards.