RecallRadar

Home → Volvo → Vn → 2004

2004 Volvo Vn Recalls & Complaints

4

open safety recalls on record

Critical

1 owner complaints filed · Severity Index 0.00 · updated 2026-08-07

The recalls

Critical04V457000

Visibility:Windshield Wiper/Washer:Motor

IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.

Remedy & full details

DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.

Serious12V510000

Seat Belts

In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant.

Remedy & full details

Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.

Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."

Serious04V405000

Power Train:Driveline:Driveshaft

THIS CAN RESULT IN THE DRIVE SHAFT COMING LOOSE FROM THE TRANSMISSION, raises the risk of A CRASH.

Remedy & full details

DEALERS WILL REMOVE AND INSTALL REMOVING NEW BOLTS, INSPECT FOR CROSS-THREADED BOLTS, AND REPLACE THE YOKE IF NECESSARY. THE RECALL BEGAN OCTOBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

ON CERTAIN TRUCKS, THE BOLTS THAT RETAIN THE UNIVERSAL JOINT TO THE YOKE AT THE TRANSMISSION MAY NOT BE TIGHTENED CORRECTLY.

Serious04V315000

Trailer Hitches:Fifth Wheel Assembly

THIS CONDITION COULD CAUSE THE FIFTH WHEEL LATCH TO RELEASE INADVERTENTLY WHEN THE PARK BRAKE IS ENGAGED, CREATING THE POTENTIAL FOR LOSS OF THE TRAILER.

Remedy & full details

DEALERS WILL ADD AN ADDITIONAL SOLENOID VALVE IN SERIES WITH THE EXISTING PNEUMATIC CIRCUIT FOR THE FIFTH WHEEL AIR RELEASE. THE RECALL BEGAN ON AUGUST 9, 2004. OWNERS SHOULD CONTACT VOLVO AT 1-800-528-6586.

ON CERTAIN TRUCKS, A MALFUNCTION IN THE SOLENOID VALVE MAY ALLOW AIR TO BE RELEASED TO FIFTH WHEEL LATCH WHEN THE PARK BRAKE IS ENGAGED.

Complaint volume

1 this model-year 6 median, same year

Volume alone is not a fault rate — popular vehicles attract more reports. Read it next to the severity mix below.

What owners reported happened

0Crashes
0Fires
0Injuries
0Deaths

Across 1 complaints. Severity Index 0.00.

Severity Index weights each complaint's reported outcome (death ×10, injury ×4, fire ×3, crash ×2) and divides by total complaints. It measures how severe reports are, not how often faults occur.

What owners report most

  1. Electrical System:Wiring:Fuses And Circuit Breakers — 1 reports

What to do

  1. Find your 17-character VIN on the driver's door jamb or the base of the windscreen.
  2. Check it against NHTSA's official lookup at nhtsa.gov/recalls — the authoritative record for your exact car.
  3. Book the repair with any franchised dealer. Safety recall work is free, with no time limit and regardless of who owns the car now.

Other model years

1996 (1) · 1998 (6) · 1999 (5) · 2000 (2) · 2001 (2) · 2003 (4) · 2004 · 2005 (2) · 2006 (4) · 2007 (3) · 2008 (2) · 2012 (2) · 2013 (2) · 2014 (1) · 2020 (2) · 2021 (2) · 2024 (7)

Numbers in brackets are open recall campaigns for that year.

Questions

Does an open recall mean the car is unsafe to drive?

Not usually. NHTSA issues a "do not drive" or "park outside" advisory when a defect is dangerous enough to keep you out of the car — those are flagged Critical above. Everything else should be repaired promptly but is not an immediate stop-driving order.

Do I pay for recall repairs?

No. Federal law requires the manufacturer to fix a safety recall free of charge, including parts and labour, whether or not you are the original owner.

Why are there complaints but no recalls?

Complaints are unverified reports filed by owners. They can prompt an investigation, but many never become recalls — either the fault isn't safety-related or it isn't widespread.

From the same data desk

Independent sites, same maintainer, same open-data standards.

TireFit
Is that tyre actually right for your car?
2,808 fitment guides
FuelFacts
What that trip really costs in fuel
Live consumption data
CostCompare
What things cost, city by city
2,123 comparisons